RUST K号涂料
（RUST KNOCKOUT®）
说 明 书
RUST KNOCKOUT® is a waterborne, corrosion fighting red metal primer that will stop rust dead
In its tracks.It can be used on new bare metal, slightly rusting metal, previously painted metal,
Galvanized metal, core-tan steel, tin and aluminum. It provides superior adhesion and rust preventive protection on all of these surfaces. When properly applied and top coated RUST KNOCKOUT Is
Guaranteed to provide up to five full years of protection from rust. RUST KNOCKOUT is heat
Resistant up to 200˚ F. It should not be used on surfaces subject to continuous water Submersion
Without being properly top coated.
RUST K号涂料（RUST KNOCKOUT®）是一种水性的，红色抗腐蚀金属底漆，可以阻断锈迹的发生。本品可以用于新的金属裸面，轻度锈蚀的金属，以前涂过漆的金属，镀锌的金属，COR-TAN钢，锡和铝。本品对所有的表面都有极佳的附着力和防锈功能。在正确的涂刷以及配合恰当的面漆的情况下，RUST K号涂料（RUST KNOCKOUT®）承诺长达五年的防锈保质期。RUST K号涂料（RUST KNOCKOUT®）可以耐受200℉（93℃）的高温。在没有涂覆合适的面漆的情况下本品不适合用于长期浸没在水下的部分的表面。
DIRECTIONS: Remove loose or scaling particles, dirt, grease, oil and other surface contaminants.
Previously rusted surfaces should be scraped to remove as much rust as possible. RUST
KNOCKOUT® may be applied by brush, roller or spray equipment. Stir well and use directly from
Can.Thinning should not be required. A small amount of water may be required for some spray
Applications. For best results apply at temperatures between 50˚ F and 90˚ F. Dry time to top
Coat: 4-6 hours with eitherawater based coating or alkyd based product. 24 hours for more
Exotic topcoats, such as an epoxy or lacquer. Always test the topcoat in an inconspicuous area to
Determine if the base coat has dried successfully.
使用说明：去除表面所有松散起皮的部分，浮尘，油脂，油剂和其他表面的污垢。先前生锈的表面要刮去可以去除的锈迹。RUST K号涂料（RUST KNOCKOUT®）可以刷涂，辊涂或喷涂。充分搅拌后直接从油漆罐中取用。无需稀释。喷涂时可以加少量水稀释。为了达到最佳效果，在环境温度50℉-90℉（10℃-32℃）之间施工。干燥4-6小时后可以涂刷水性或者醇酸树脂面漆。干燥24小时后可以涂刷其它的面漆，如环氧树脂或漆。建议在底漆完全干燥后在不显眼的区域试涂面漆。
Coverage: Application should not exceed 250 square feet per gallon. This will provide a dry film thickness of 3 mils, which is required for good rust protection. Do not apply at a higher spread rate since rust protection will be reduced. If you need asecond coat of primer, allow 4 hours of dry
Time between coats.
涂覆面积：要取得优良的防锈效果，每加仑涂覆面积不要超过250平方英尺（23.2平方米），可以产生3密耳（76微米）厚度的干膜。不要随意提高涂布率，以免降低防锈的效果。如果需要涂刷第二层底漆，请间隔4个小时的干燥时间。
Clean Up: Clean all equipment immediately with water. RUST KNOCKOUT® dries very quickly and
Can be difficult to remove once dry.
清洁：施工完毕后立即用水清洗设备。RUST K号涂料（RUST KNOCKOUT®）会快速地干燥，一旦干燥将很难去除。
Warning: If you scrape sand or remove old paint, you may release, you may release lead dust. LEAD IS TOXIC.EXPOSURE TO LEAD DUST CAN CAUSE SERIOUSILLNESS, SUCH AS BRAIN
DAMAGE, ESPECIALLY IN CHILDREN .PREGNANT WOMEN SHOULD ALSO AVOID EXPOSURE.
Wear a NIOSH-approved respirator to control lead exposure. Clean up carefully with a HEPA vacuum and a wet mop. Before you start, find out how to protect yourself and your family by contacting the National Lead Information Hotline at 1-800-424-LEAD or log on to
www.epa.gov/lead.警告：在刮除或用砂纸打磨去除旧的涂层时，会释放出铅尘，铅尘有毒。暴露在铅尘中会导致严重的疾病，比如脑部疾患，尤其是儿童和怀孕的妇女要避免暴露其中。使用美国国家职业安全与卫生研究院（NIOSH）认可的防毒面具来防止暴露在铅尘中。使用高效空气过滤吸尘器和湿抹布小心清洁。在施工前可以拨打美国国家铅信息热线1-800-424-LEAD或者登录
www.epa.gov/lead来了解如何保护您和您的家人。
Guarantee: When RUST KNOCKOUT® is applied in accordance with label directions and is covered by a suitable topcoat, it shall be guaranteed to prevent rust for up to five full years. RUST KNOCKOUT will stop existing rust and prevent new rust for a period of five years. The maximum liability of ADVANCED PROTECTIVE PRODUCTS, INC. under this exclusive warranty shall be replacement of product or refund of purchase price at manufacture's option
承诺：RUST K号涂料（RUST KNOCKOUT®）按照说明书涂刷并覆盖以合适的面漆，我们承诺防锈功能可长达五年。RUST K号涂料（RUST KNOCKOUT®）不仅可以停止正在发生的生锈反应，同时能防止新的锈迹产生，有效期可达五年。美国高级防护用品有限公司（ADVANCED PROTECTIVE PRODUCTS,INC.）作为制造商可以承诺的最大责任是更换产品或者退还购货款 。
KEEP OUT OF REACH OF CHILDREN 存放于儿童接触不到的地方
DO NOT TAKE INTERNALLY 不可内服
USE ONLY WITH ADEQUATE VENTILATION 必须在通风良好的环境下施工
CLOSE CONTAINER AFTER EACH USE 每次使用后请密闭容器
PROTECT FROM FREEZING 防止冻结
MAXIMUM VOC CONTENT100 GRAMS/LITER 本品包含的最高VOC（挥发性有机化合物） 100克/升
